2000 new flyer d60hf
ZUSAMMENFASSUNG
ON CERTAIN TRANSIT BUSES, THE U-JOINT ASSEMBLIES HAVE INADEQUATE SPLINE ENGAGEMENT ON ONE OF THE TWO END YOKES.
DIE KONSEQUENZ
-
ABHILFE
THE U-JOINT ASSEMBLY WILL BE INSPECTED AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JUNE 10, 2007. OWNERS MAY CONTACT NEW FLYER AT 1-204-934-4874.
Notizen
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
ZUSAMMENFASSUNG
CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS." THE SERVICE BRAKE RELEASE TIMING AND PARK BRAKE APPLY TIMING ARE OUT OF COMPLIANCE WITH THE STANDARD.
DIE KONSEQUENZ
-
ABHILFE
TO RESOLVE THE ISSUE OF NONCOMPLIANCE WITH THE SERVICE BRAKE RELEASE TIMING, DEALERS WILL RE-ROUTE THE REDUNDANT SIGNAL LINE TO THE CENTER AXLE RELAY VALVE AND THE CENTER AND REAR RELAY VALVES WILL BE SWAPPED. OWNER NOTIFICATION BEGAN JULY 17, 2003. OWNERS SHOULD CONTACT NEW FLYER AT 1-204-982-8400.
Notizen
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
ZUSAMMENFASSUNG
ON CERTAIN TRANSIT BUSES, THE CENTER AXLE WHEEL END BRAKES MAY NOT RELEASE AFTER BEING PARKED FOR AN EXTENDED PERIOD OF TIME.
DIE KONSEQUENZ
-
ABHILFE
NEW FLYER WILL INSTALL AN ADDITIONAL AIR SYSTEM R14 RELAY VALVE, #4 NOTCH AUTOMATIC SLACK ADJUSTERS, AND TYPE 30 LONG STOKE BRAKE CHAMBERS ON THE CENTER AXLE; THE LOGIC CONTROL MODULE WILL BE REPROGRAMMED, ADD NEW ABS COMPONENTS (SENSORS, SPEED RINGS AND HARNESSES) IF NOT ALREADY EQUIPPED WITH ABS; AND WILL REVISE PLC PROGRAMMING. OWNERS MAY CONTACT NEW FLYER AT 1-204-982-8400.
Notizen
CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
ZUSAMMENFASSUNG
NEW FLYER IS RECALLING 431 MY 1996-2001 D60HF DIESEL TRANSIT BUSES EQUIPPED WITH A ROOFTOP AIR CONDITIONING EVAPORATOR. THE EVAPORATOR DRAIN LINES MAKE CONTACT WITH COMPONENTS (BALLAST ASSEMBLIES) WITHIN THE INTERIOR LIGHTING PANEL BELOW THE DRAIN LINE PORT. THIS CAN RESULT IN EITHER DAMAGE TO THE DRAIN LINE, WHICH INTRODUCES MOISTURE INTO THE LIGHTING PANEL, OR RESTRICTION OF THE LINE WHICH RESULTS IN A BACK-UP AND OVERFLOW OF MOISTURE THROUGH THE FRESH AIR RETURN VENT AND BACK INTO THE LIGHTING PANEL.
DIE KONSEQUENZ
-
ABHILFE
NEW FLYER WILL INCORPORATE AN ELBOW FITTING INTO THE DRAIN LINE WHERE IT ENTERS THE LIGHTING PANEL FROM THE ROOF, WHICH WILL PROMOTE CLEARANCE BETWEEN THE LINE AND THE BALLAST ASSEMBLY. THE RECALL BEGAN ON FEBRUARY 6, 2008. OWNERS MAY CONTACT NEW FLYER AT 1-204-934-4803.
Notizen
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
