2000 mci 102dl3
SUMMARY
MOTORHOMES EQUIPPED WITH DRAG LINK ASSEMBLIES CONTAINING 20-EDL MODEL BALL SOCKETS AND MANUFACTURED BY TRW. CERTAIN OF THE TIE ROD BALL-SOCKET BEARINGS HAVE A BELOW-SPECIFICATION CASE DEPTH AND/OR HARDNESS, WHICH CAN LEAD TO PREMATURE WEAR OF THE SOCKET.
CONSEQUENCE
-
REMEDY
DEALERS WILL REPLACE THE DEFECTIVE DRAG LINKS. OWNER/DISTRIBUTOR NOTIFICATION BEGAN APRIL 18, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MCI AT 1-800-241-2941 OR TRW CUSTOMER SERVICE AT 1-866-280-3287.
NOTES
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
SUMMARY
VEHICLE DESCRIPTION: MOTOR HOME CHASSIS BUILT WITH BENDIX AIR ABS WITH AN EC-17 1030R ELECTRONIC CONTROL UNIT (ECU), THERE HAVE BEEN REPORTS OF UNWANTED ABS ACTIVATION AT LOW SPEEDS CAUSED BY 1) CHAFED ABS WHEEL SPEED SENSOR WIRES ON ROTATING PARTS OR 2) A DAMAGED COMPONENT AT THE WHEEL END THAT GENERATES A CERTAIN TYPE OF ERRATIC SENSOR SIGNAL.
CONSEQUENCE
-
REMEDY
DEALERS WILL REPLACE THE ABS ECU.
NOTES
OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING SEPTEMBER 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MCI AT 1-800-241-2947. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
SUMMARY
ON CERTAIN MOTOR COACHES, THE BOOST CONNECTOR HOUSING CAN FAIL OVER TIME, EXPOSING THE POSITIVE AND NEGATIVE TERMINALS.
CONSEQUENCE
-
REMEDY
CUSTOMERS ARE BEING ADVISED TO REMOVE THE BOOST CONNECTOR AND DISCARD IT. CUSTOMERS WILL BE OFFERED A NEW DESIGN BOOST CONNECTOR AS AN ALTERNATIVE AT NO COST. THE RECALL BEGAN ON JANUARY 2, 2007. OWNERS MAY CONTACT MCI AT 1-800-241-2947.
NOTES
MCI RECALL NO. 274. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
SUMMARY
Motor Coach Industries (MCI) is recalling certain model year 2000-2012 D, E, G and J series coaches manufactured January 2000 through June 2011 and equipped with Sure Power battery equalizers containing a particular epoxy sealing, aka 'potting', compound. The specific potting compound used in the subject products for insulation was found to be capable of conducting electricity after being exposed to heat.
CONSEQUENCE
-
REMEDY
MCI will notify owners, and Sure Power will replace the equalizers, free of charge. Owners may contact MCI at 1-847-285-2000. This campaign is MCI service bulletin 401.
NOTES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
