2000 freightliner mt-45
SUMMARY
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH TRW TIE ROD ENDS ON CERTAIN MERITOR AXLES. THE TIE ROD AND DRAG LINK BALL STUD ENDS CONTAIN BEARINGS THAT ARE BELOW THE SPECIFIED CASE DEPTH AND/OR HARDNESS.
CONSEQUENCE
-
REMEDY
DEALERS WILL REMOVE AND REPLACE ALL AFFECTED TIE RODS AND DRAG LINKS WITH DIFFERENT DESIGNED ENDS. OWNER NOTIFICATION BEGAN NOVEMBER 8, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
NOTES
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
SUMMARY
VEHICLE DESCRIPTION: STEP VANS. WATER COULD ENTER THE ELECTRICAL RELAYS RESULTING IN AN ELECTRICAL SHORT.
CONSEQUENCE
-
REMEDY
DEALERS WILL INSTALL A NEW SEALED RELAY AND FUSE BOX WITH SEALED RELAYS. OWNER NOTIFICATION BEGAN JULY 23, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
NOTES
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
SUMMARY
VEHICLE DESCRIPTION: STEP VANS. THE BACK-UP BRAKE PUMP WAS WIRED TO A 25 AMP FUSED CIRCUIT INSTEAD OF THE REQUIRED 50 AMP FUSED CIRCUIT. IF THE BACK-UP HYDRAULIC BRAKE PUMP WERE TO ENGAGE DUE TO A FAILURE IN THE PRIMARY BRAKE ASSIST SYSTEM OR THE BRAKES ARE APPLIED WITHOUT THE ENGINE RUNNING, THE FUSE COULD BLOW.
CONSEQUENCE
-
REMEDY
DEALERS WILL REWIRE THE BACK-UP BRAKE PUMP CIRCUIT. OWNER NOTIFICATION BEGAN JULY 23, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
NOTES
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
SUMMARY
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS, SHUTTLE BUSES, TRANSIT BUSES AND STEP VANS EQUIPPED WITH ALLISON 1000 OR 2400 SERIES TRANSMISSIONS. THESE TRANSMISSIONS CAN EXPERIENCE PARK PAWL TO REAR COVER INTERFERENCE DUE TO AN OUT OF FLATNESS CONDITION.
CONSEQUENCE
-
REMEDY
ALLISON TRANSMISSION IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL REMOVE THE TRANSMISSION FROM THE VEHICLE, REPLACE THE PARK PAWL, AND REINSTALL THE TRANSMISSION IN THE VEHICLE. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING SEPTEMBER 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ALLISON AT 1-800-252-5283 OR FREIGHTLINER AT 1-800-547-0712.
NOTES
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
SUMMARY
CERTAIN VAN CHASSIS WITH SINGLE REAR TIRES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THE REAR TIRE RATING WAS INCORRECTLY ENTERED IN THE GAWR/GVWR CALCULATION PROGRAM ON CERTAIN SINGLE REAR TIRES. THE REAR GAWR AND GVWR WILL BE INCORRECT WHEN THE GAWR IS LIMITED BY THE TIRE CAPACITY ON CHASSIS WITH THESE TIRES.
CONSEQUENCE
-
REMEDY
DEALERS WILL MAIL NEW CHASSIS IDENTIFICATION LABELS WITH THE CORRECT GAWR, GVWR, AND TIRE INFORMATION. THE RECALL BEGAN ON SEPTEMBER 12, 2005. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.
NOTES
FREIGHTLINER RECALL NO. FL-444. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-327-4236.
