2003 amtran fe
SUMMARY
CERTAIN FLAT FLOOR SCHOOL BUSES WERE BUILT WITH THE INCORRECT HYDRAULIC BRAKE DROP HOSES FROM FRAME TO AXLE. THE HOSES INSTALLED WERE 3 INCHES SHORTER THAN SPECIFIED AND MAY FAIL FROM TENSION CAUSED BY AXLE ARTICULATION.
CONSEQUENCE
-
REMEDY
DEALERS WILL REPLACE THE HOSES AND BLEED THE BRAKE SYSTEM. OWNER NOTIFICATION BEGAN ON OCTOBER 9, 2003. OWNERS SHOULD CONTACT IC AT 1-800-843-5615.
NOTES
IC RECALL NO. 03304. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
SUMMARY
ON CERTAIN "SPECIAL NEEDS" SCHOOL BUSES EQUIPPED WITH SUR-LOC "L" WHEELCHAIR TRACKS, THE LIFT MOUNTING BOLTS COULD CORRODE IF MOISTURE OCCURS IN THE TREATED PLYWOOD FLOOR.
CONSEQUENCE
-
REMEDY
DEALERS WILL REPLACE THE SUR-LOC "L" TRACKS WITH PROTECTED TRACKS AND MOUNTING HARDWARE. ALSO, LIFT FLOOR-MOUNTING BOLTS WILL BE REPLACED. OWNER NOTIFICATION IS EXPECTED TO BEGIN MARCH 19, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT IC AT 1-800-843-5615.
NOTES
IC RECALL NO. 04301. CUSTOMER'S CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236). HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
SUMMARY
CE MODEL SCHOOL BUSES WHICH FAIL TO COMPLY TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 221, SCHOOL BUS BODY JOINT STRENGTH. THE ROOF TOP SHEET MAY BE IMPROPERLY LOCATED, REDUCING THE MATERIAL EDGE DISTANCE AT THE RIVET LINE.
CONSEQUENCE
-
REMEDY
IC WILL NOTIFY ITS CUSTOMERS AND WILL PROVIDE INSPECTION AND REPAIR INSTRUCTION. THE RECALL BEGAN ON JANUARY 25, 2005. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT IC CUSTOMER SERVICE AT (WE DO NOT YET HAVE A TELEPHONE NUMBER FOR THIS CAMPAIGN.)
NOTES
IC RECALL NO. 03305. ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
SUMMARY
CERTAIN FE MODEL SCHOOL BUSES MANUFACTURED FROM OCTOBER 14, 1991, AND MARCH 4, 2003. A GAP BETWEEN THE MODESTY PANEL AND THE WHEEL WELL LOCATED BEHIND THE DRIVER'S SEAT CAN BE CREATED IF THE PANEL IS BENT OUT OF POSITION. UNDER THE PANEL, THE EDGES ARE SHARP AND JAGGED.
CONSEQUENCE
-
REMEDY
IC WILL NOTIFY ITS CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. OWNER NOTIFICATION IS EXPECTED TO BEGIN JANUARY 20, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT IC CORPORATION COMPLIANCE DEPARTMENT TOLL-FREE AT 1-800-843-5615. CUSTOMERS CAN LOCATE THE NEAREST DEALER BY CALLING 1-800-993-7686.
NOTES
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
SUMMARY
CERTAIN 1998, 2000-2005 MY CE, FE, AND RE SCHOOL BUSES BUILT WITH ONE OR MORE CE WHITE 30-INCH CHILD RESTRAINT SEATS AND MANUFACTURED BETWEEN MARCH 25, 1998 AND AUGUST 24, 2004. THE SEAT CUSHION RETENTION MAY NOT RETAIN THE SEAT IN ALL CIRCUMSTANCES.
CONSEQUENCE
-
REMEDY
IC CORP WILL NOTIFY ITS CUSTOMERS AND WILL REPAIR THE CUSHION BY ADDING A CLIP TO THE CUSHION TYING IT TO THE SEAT FRAME. THE RECALL BEGAN ON OCTOBER 5, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT IC COMPLIANCE DEPARTMENT AT 1-800-843-5615.
NOTES
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
SUMMARY
CERTAIN SURE-LOK WHEELCHAIR TIE-DOWN SECUREMENT ASSEMBLIES P/N 8625-13 FOR USE ON CERTAIN SCHOOL AND TRANSIT BUSES. THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY MAY BE OUT OF ALIGNMENT CAUSING THE LOAD PAWL NOT TO FULLY SEAT IN THE SPROCKET TEETH.
CONSEQUENCE
-
REMEDY
SURE-LOK WILL NOTIFY ITS CUSTOMERS AND REPLACE THE DEFECTIVE PART FREE OF CHARGE. THE RECALL BEGAN AUGUST 16, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SURE-LOK CUSTOMER SERVICE AT 866-787-3565.
NOTES
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
SUMMARY
CERTAIN MY 2001-2005 AMTRAN/IC CORPORATION CE, FE, AND RE SCHOOL BUSES EQUIPPED WITH SURE-LOK WHEELCHAIR TIE-DOWN SECUREMENT ASSEMBLIES P/N 8625-13. THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY MAY BE OUT OF ALIGNMENT CAUSING THE LOAD PAWL NOT TO FULLY SEAT IN THE SPROCKET TEETH.
CONSEQUENCE
-
REMEDY
SURE-LOK WILL NOTIFY IC'S CUSTOMERS AND REPAIR THE BUSES ON IC'S BEHALF AT NO COST TO THE CUSTOMER. THE RECALL BEGAN AUGUST 16, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SURE-LOK AT 1-908-231-1804.
NOTES
-
SUMMARY
CERTAIN FE SCHOOL AND COMMERCIAL BUSES BUILT WITH CE WHITE DRIVER SEATS WITH A PEDESTAL STYLE MOUNT AND MANUFACTURED BETWEEN JANUARY 10, 1992 THROUGH FEBRUARY 24, 2004. THESE PEDESTALS CAN DEVELOP CRACKS RENDERING THE SEAT UNSTABLE.
CONSEQUENCE
-
REMEDY
IC WILL NOTIFY ITS CUSTOMERS AND REPAIR THE SEAT BY REPLACING THE UPPER PORTION OF THE ASSEMBLY WITH A MORE ROBUST DESIGN. THE RECALL BEGAN JUNE 3, 2005. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT IC COMPLIANCE DEPARTMENT AT 1-800-843-5615.
NOTES
IC PREDICTS PARTS WILL BE AVAILABLE IN THE SECOND WEEK OF MAY 2005. CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
SUMMARY
ON CERTAIN SCHOOL BUS WARNING LAMPS, A STATIC ELECTRICITY DISCHARGE CAN OCCUR DURING NORMAL SERVICES OR HANDLING. THIS DISCHARGE CAN POTENTIALLY INITIATE A CHEMICAL REACTION OF MATERIALS WITHIN THE LAMP WHICH COULD CAUSE THE LENS TO FRACTURE.
CONSEQUENCE
-
REMEDY
SOUND OFF WILL NOTIFY THE CUSTOMERS AND MAKE ARRANGEMENTS TO GO OUT TO THE OPERATING FACILITIES AND REPLACE THE WARNING LAMPS FREE OF CHARGE. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUND OFF AT 800-338-7337 OR IC AT 501-505-2190.
NOTES
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
SUMMARY
CERTAIN SCHOOL BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE." THESE BUSES DO NOT COMPLY WITH THE EMERGENCY EXIT REQUIREMENTS.
CONSEQUENCE
-
REMEDY
DEALERS WILL ADD ONE ROOF EXIT IN THE CENTER OF THE PASSENGER COMPARTMENT. ALL OWNERS HAVE BEEN NOTIFIED AND ARRANGEMENTS MADE TO REMEDY THEIR BUSES.
NOTES
IC RECALL NO. 03302. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
SUMMARY
ON CERTAIN BUSES EQUIPPED WITH HYDRAULIC BRAKES, THE MASTER CYLINDER WAS DAMAGED DURING THE FILL AND BLEED PROCEDURE.
CONSEQUENCE
-
REMEDY
DEALERS WILL REPLACE THE MASTER CYLINDER. OWNER NOTIFICATION BEGAN JANUARY 27, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT IC CORPORATION AT 1-800-993-7686.
NOTES
IC RECALL NO. 02303. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
