2002 amtran fe
SUMMARY
VEHICLE DESCRIPTION: CERTAIN BUSES WERE BUILT WITH AN IMPROPER CONNECTION OF THE HEATER HARNESS FROM THE HEATER SWITCH TO THE CONNECTOR JUST OUTSIDE THE HEATER UNIT. THE ASSEMBLY LEFT A LOOSE HOT WIRE IN THE HEATER HARNESS WITH AN UNPROTECTED TERMINAL THAT COULD CAUSE A DIRECT SHORT. THIS WIRE IS PROTECTED WITH A 20-AMPERE CIRCUIT PROTECTION, BUT IN A RARE CASE COULD CAUSE A FIRE.
CONSEQUENCE
-
REMEDY
OWNERS WILL BE PROVIDED WITH INSTRUCTIONS ON HOW TO REPAIR THE DEFECT. THE REPAIR PROCEDURE FOR THIS DEFECT WILL REQUIRE PLACING THE CONNECTORS CORRECTLY IN THE TERMINALS TO THE HIGH-SPEED BLOWER RELAY AND HARNESS CONNECTION AT THE HEATER. OWNER NOTIFICATION BEGAN DECEMBER 18, 2001. OWNERS WHO DO NOT RECEIVE THE FREE INSTRUCTIONS WITHIN A REASONABLE TIME SHOULD CONTACT AMTRAN AT 1-800-843-5615.
NOTES
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
SUMMARY
VEHICLE DESCRIPTION: CERTAIN BUSES WERE BUILT WITH A WIRING DIAGRAM DECAL THAT SHOWS THE CIRCUIT PROTECTION SIZE OF 30 AMPERES INSTEAD OF 20 AMPERES FOR THE HEATER SUPPLY CIRCUITS.
CONSEQUENCE
-
REMEDY
OWNERS WILL BE PROVIDED WITH A STRIP AND INSTALLATION INSTRUCTIONS THAT SHOULD BE PLACED OVER THE INCORRECT INFORMATION ON THE CURRENT DECAL. OWNER NOTIFICATION BEGAN DECEMBER 21, 2001. OWNERS WHO DO NOT RECEIVE THE FREE STRIP AND INSTALLATION INSTRUCTIONS WITHIN A REASONABLE TIME SHOULD CONTACT AMTRAN AT 1-800-993-7686.
NOTES
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
SUMMARY
VEHICLE DESCRIPTION: SCHOOL AND TRANSIT BUSES EQUIPPED WITH 39-INCH FLIP SEATS. THE FLIP SEATS COULD BIND IN THE OCCUPIED POSITION AND NOT RETURN TO THE STORED POSITION WHEN NOT OCCUPIED. THE CUSHION FRAME SUPPORT BAR SLIDES OFF THE SEAT SUPPORT PAD, WHICH COULD RETAIN THE SEAT IN THE OCCUPIED POSITION.
CONSEQUENCE
-
REMEDY
OWNERS WILL BE PROVIDED WITH INSTRUCTIONS AND PARTS TO REPAIR THE SEATS FREE OF CHARGE. OWNER NOTIFICATION BEGAN OCTOBER 23, 2001. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AMTRAN AT 800-843-5615.
NOTES
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
SUMMARY
CE MODEL SCHOOL BUSES WHICH FAIL TO COMPLY TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 221, SCHOOL BUS BODY JOINT STRENGTH. THE ROOF TOP SHEET MAY BE IMPROPERLY LOCATED, REDUCING THE MATERIAL EDGE DISTANCE AT THE RIVET LINE.
CONSEQUENCE
-
REMEDY
IC WILL NOTIFY ITS CUSTOMERS AND WILL PROVIDE INSPECTION AND REPAIR INSTRUCTION. THE RECALL BEGAN ON JANUARY 25, 2005. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT IC CUSTOMER SERVICE AT (WE DO NOT YET HAVE A TELEPHONE NUMBER FOR THIS CAMPAIGN.)
NOTES
IC RECALL NO. 03305. ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
SUMMARY
CERTAIN FE MODEL SCHOOL BUSES MANUFACTURED FROM OCTOBER 14, 1991, AND MARCH 4, 2003. A GAP BETWEEN THE MODESTY PANEL AND THE WHEEL WELL LOCATED BEHIND THE DRIVER'S SEAT CAN BE CREATED IF THE PANEL IS BENT OUT OF POSITION. UNDER THE PANEL, THE EDGES ARE SHARP AND JAGGED.
CONSEQUENCE
-
REMEDY
IC WILL NOTIFY ITS CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. OWNER NOTIFICATION IS EXPECTED TO BEGIN JANUARY 20, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT IC CORPORATION COMPLIANCE DEPARTMENT TOLL-FREE AT 1-800-843-5615. CUSTOMERS CAN LOCATE THE NEAREST DEALER BY CALLING 1-800-993-7686.
NOTES
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
SUMMARY
CERTAIN 1998, 2000-2005 MY CE, FE, AND RE SCHOOL BUSES BUILT WITH ONE OR MORE CE WHITE 30-INCH CHILD RESTRAINT SEATS AND MANUFACTURED BETWEEN MARCH 25, 1998 AND AUGUST 24, 2004. THE SEAT CUSHION RETENTION MAY NOT RETAIN THE SEAT IN ALL CIRCUMSTANCES.
CONSEQUENCE
-
REMEDY
IC CORP WILL NOTIFY ITS CUSTOMERS AND WILL REPAIR THE CUSHION BY ADDING A CLIP TO THE CUSHION TYING IT TO THE SEAT FRAME. THE RECALL BEGAN ON OCTOBER 5, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT IC COMPLIANCE DEPARTMENT AT 1-800-843-5615.
NOTES
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
SUMMARY
CERTAIN SURE-LOK WHEELCHAIR TIE-DOWN SECUREMENT ASSEMBLIES P/N 8625-13 FOR USE ON CERTAIN SCHOOL AND TRANSIT BUSES. THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY MAY BE OUT OF ALIGNMENT CAUSING THE LOAD PAWL NOT TO FULLY SEAT IN THE SPROCKET TEETH.
CONSEQUENCE
-
REMEDY
SURE-LOK WILL NOTIFY ITS CUSTOMERS AND REPLACE THE DEFECTIVE PART FREE OF CHARGE. THE RECALL BEGAN AUGUST 16, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SURE-LOK CUSTOMER SERVICE AT 866-787-3565.
NOTES
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
SUMMARY
CERTAIN MY 2001-2005 AMTRAN/IC CORPORATION CE, FE, AND RE SCHOOL BUSES EQUIPPED WITH SURE-LOK WHEELCHAIR TIE-DOWN SECUREMENT ASSEMBLIES P/N 8625-13. THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY MAY BE OUT OF ALIGNMENT CAUSING THE LOAD PAWL NOT TO FULLY SEAT IN THE SPROCKET TEETH.
CONSEQUENCE
-
REMEDY
SURE-LOK WILL NOTIFY IC'S CUSTOMERS AND REPAIR THE BUSES ON IC'S BEHALF AT NO COST TO THE CUSTOMER. THE RECALL BEGAN AUGUST 16, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SURE-LOK AT 1-908-231-1804.
NOTES
-
SUMMARY
CERTAIN FE SCHOOL AND COMMERCIAL BUSES BUILT WITH CE WHITE DRIVER SEATS WITH A PEDESTAL STYLE MOUNT AND MANUFACTURED BETWEEN JANUARY 10, 1992 THROUGH FEBRUARY 24, 2004. THESE PEDESTALS CAN DEVELOP CRACKS RENDERING THE SEAT UNSTABLE.
CONSEQUENCE
-
REMEDY
IC WILL NOTIFY ITS CUSTOMERS AND REPAIR THE SEAT BY REPLACING THE UPPER PORTION OF THE ASSEMBLY WITH A MORE ROBUST DESIGN. THE RECALL BEGAN JUNE 3, 2005. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT IC COMPLIANCE DEPARTMENT AT 1-800-843-5615.
NOTES
IC PREDICTS PARTS WILL BE AVAILABLE IN THE SECOND WEEK OF MAY 2005. CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
SUMMARY
CERTAIN SCHOOL BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE." THESE BUSES DO NOT COMPLY WITH THE EMERGENCY EXIT REQUIREMENTS.
CONSEQUENCE
-
REMEDY
DEALERS WILL ADD ONE ROOF EXIT IN THE CENTER OF THE PASSENGER COMPARTMENT. ALL OWNERS HAVE BEEN NOTIFIED AND ARRANGEMENTS MADE TO REMEDY THEIR BUSES.
NOTES
IC RECALL NO. 03302. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
