2000 thomas mvp er
RÉSUMÉ
ON CERTAIN SCHOOL AND TRANSIT BUSES, THE WHEEL LUG NUT MAY NOT TIGHTEN COMPLETELY.
CONSÉQUENCE
-
REMÈDE
DEALERS WILL INSTALL NEW WHEEL STUDS. OWNER NOTIFICATION BEGAN FEBRUARY 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 336-889-4871.
REMARQUES
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
RÉSUMÉ
ON CERTAIN SCHOOL BUSES, MISALIGNMENT OF THE FAN DRIVE SYSTEM COMPONENTS CAN CAUSE PREMATURE BELT AND PULLEY BEARING WEAR.
CONSÉQUENCE
-
REMÈDE
DEALERS WILL REPLACE THE FAN BELT, IDLER PULLEY, AND BELT TENSIONER AND THE PULLEY'S LASER WILL BE ALIGNED. OWNER NOTIFICATION BEGAN JUNE 10, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
REMARQUES
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
RÉSUMÉ
VEHICLE DESCRIPTION: CERTAIN SCHOOL BUSES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 121, "AIR BRAKE SYSTEMS." THESE VEHICLES DO NOT COMPLY DUE TO THE LOW AIR WARNING SYSTEM DETECTING PRESSURE IN ONLY ONE RESERVOIR SYSTEM AND NOT BOTH AS REQUIRED.
CONSÉQUENCE
-
REMÈDE
DEALERS WILL CORRECT THE LOW AIR PRESSURE SWITCH WIRING. OWNER NOTIFICATION BEGAN JULY 27, 2001. OWNER NOTIFICATION IS EXPECTED TO BEGIN OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 336-881-7219.
REMARQUES
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
RÉSUMÉ
VEHICLE DESCRIPTION: SCHOOL AND TRANSIT BUSES EQUIPPED WITH SAFETY BELT ASSEMBLIES PRODUCED BY AM-SAFE. ON SOME SEAT BELTS, THE BUCKLE AND CONNECTOR MAY UNLATCH DURING A COLLISION.
CONSÉQUENCE
-
REMÈDE
AM-SAFE NOTIFIED THOMAS BUILT'S CUSTOMERS TO RETURN THEIR VEHICLE TO AN AUTHORIZED DEALER TO HAVE THE SEAT BELTS REPAIRED FREE OF CHARGE. OWNER NOTIFICATION BEGAN SEPTEMBER 21, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 1-336-889-4871.
REMARQUES
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
RÉSUMÉ
VEHICLE DESCRIPTION: SCHOOL BUS CHASSIS AND EMERGENCY VEHICLES BUILT WITH BENDIX AIR ABS WITH AN EC-17 1030R ELECTRONIC CONTROL UNIT (ECU), THERE HAVE BEEN REPORTS OF UNWANTED ABS ACTIVATION AT LOW SPEEDS CAUSED BY 1) CHAFED ABS WHEEL SPEED SENSOR WIRES ON ROTATING PARTS OR 2) A DAMAGED COMPONENT AT THE WHEEL END THAT GENERATES A CERTAIN TYPE OF ERRATIC SENSOR SIGNAL.
CONSÉQUENCE
-
REMÈDE
DEALERS WILL REPLACE THE ABS ECU.
REMARQUES
OWNER NOTIFICATION BEGAN AUGUST 29, 2000, TO SCHOOL BUSES AND EMERGENCY VEHICLE CUSTOMERS. OWNERS OF THE REMAINING POPULATION WERE SENT LETTERS ON SEPTEMBER 9, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
RÉSUMÉ
VEHICLE DESCRIPTION: CERTAIN SCHOOL BUSES AND TRANSIT BUSES EQUIPPED WITH NATIONAL SEATING'S SERIES 93B-SB DRIVER SEAT. A BRACKET ATTACHING THE GAS SPRING SHOCK TO THE HEIGHT ADJUSTER OF THE SEAT CAN DEFORM AND BREAK. THIS BRACKET IS LOCATED AT THE TOP OF THE HEIGHT ADJUSTER.
CONSÉQUENCE
-
REMÈDE
DEALERS WILL REPLACE THE SEAT BASE AND ADD REINFORCEMENT TO THE SEAT ASSEMBLY
REMARQUES
OWNER NOTIFICATION BEGAN FEBRUARY 9, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
RÉSUMÉ
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS AND SCHOOL BUS CHASSIS BUILT WITH BENDIX AIR ABS WITH AN EC-17 1030R ELECTRONIC CONTROL UNIT (ECU), THERE HAVE BEEN REPORTS OF UNWANTED ABS ACTIVATION AT LOW SPEEDS CAUSED BY 1) CHAFED ABS WHEEL SPEED SENSOR WIRES ON ROTATING PARTS OR 2) A DAMAGED COMPONENT AT THE WHEEL END THAT GENERATES A CERTAIN TYPE OF ERRATIC SENSOR SIGNAL.
CONSÉQUENCE
-
REMÈDE
DEALERS WILL REPLACE THE ABS ECU.
REMARQUES
OWNER NOTIFICATION BEGAN AUGUST 29, 2000, TO SCHOOL BUSES AND EMERGENCY VEHICLE CUSTOMERS. OWNERS OF THE REMAINING POPULATION WERE SENT LETTERS ON SEPTEMBER 9, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
RÉSUMÉ
CERTAIN 1998-2003 MY FREIGHTLINER FS-65 SCHOOL BUS CHASSIS AND MB-45, MB-55, AND XB SHUTTLE BUS CHASSIS, AND THOMAS BUILT BUS: MVP-ER AND MVP-EF SCHOOL BUS AND NON-SCHOOL BUS MODELS EQUIPPED WITH CUMMINS ISB DIESEL ENGINES AND EQUIPPED WITH FEDERAL-MOGAL 12 AND 24 VOLT FUEL LIFT PUMPS. THE FUEL PUMP COULD FAIL TO TRANSFER FUEL APPROPRIATELY CREATING AN ENGINE STALL CONDITION.
CONSÉQUENCE
-
REMÈDE
CUMMINS WILL NOTIFY THE CUSTOMERS OF FREIGHTLINER AND THOMAS BUILT AND REPLACE THE FUEL LIFT PUMP FREE OF CHARGE. OWNERS MAY CONTACT CUMMINS AT 1-800-DIESELS.
REMARQUES
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
RÉSUMÉ
CERTAIN MY 2000 THROUGH 2003 THOMAS BUILT HDX AND MVP-ER SCHOOL BUSES MANUFACTURED BETWEEN APRIL 23, 2000, AND NOVEMBER 14, 2003. THE SERVICE AIR BRAKE PEDAL, FOR BOTH NON-ADJUSTABLE AND ADJUSTABLE BRAKE PEDALS, MAY CONTACT THE FRONT STRUCTURE ON THE BUS, LIMITING THE MAXIMUM BRAKE FORCE AVAILABLE.
CONSÉQUENCE
-
REMÈDE
THOMAS BUILT WILL NOTIFY OWNERS AND REPAIR THE AFFECTED BUSES FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 14, 2007. OWNERS CAN CONTACT THOMAS BUILT AT 336-889-4871 OR CONTACT FREIGHTLINER AT 800-547-0712.
REMARQUES
FREIGHTLINER RECALL NO. FL-493. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
RÉSUMÉ
ON CERTAIN SCHOOL OR TRANSIT BUSES WITH PASSENGER SEAT BELTS WITH RETRACTORS, THE COVER HALVES FOR THE RETRACTABLE PORTION OF THE BELT CAN SEPARATE COMPLETELY AND RELEASE THE SEAT BELT CONNECTOR. IF THIS OCCURS, ONE OF THE LOAD BEARING PINS IN THE CONNECTOR COULD SEPARATE FROM THE CONNECTOR AND RENDER THE SEAT BELT UNUSABLE. IN THE EVENT OF A CRASH, THE SEAT OCCUPANT WOULD NOT BE PROPERLY RESTRAINED RESULTING IN AN INJURY. THE SEAT BELT SUPPLIER, AMSAFE, WILL PROVIDE A SNAP ON "OVER-COVER" TO OWNERS TO PREVENT THE SEAT BELT COVER FROM SEPARATING.
CONSÉQUENCE
-
REMÈDE
DEALERS WILL PROVIDE A PLASTIC OUTER COVER THAT SNAPS OVER THE EXISTING COVER ON UNITS IN THE FIELD AND WILL REPLACE BROKEN SEAT BELTS FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 336-841-5924 OR AMSAFE AT 574-266-8330.
REMARQUES
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
RÉSUMÉ
DAIMLER TRUCKS IS RECALLING 243,435 MY 1995-2008 THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 1994, AND MARCH 10, 2008. (ADDITIONAL BUSES HAVE BEEN ADDED TO THIS RECALL CAMPAIGN. PLEASE SEE SUPPLEMENTAL REPORT NO. 4) THE EMERGENCY EXIT DOOR HANDLE BEGINS CORRODING AROUND THE SECURING ROLL PIN AND SQUARE DRIVE MECHANISM CAUSING THE PROTECTIVE FINISH TO CHIP AND FLAKE. CONTINUED CORROSION AND PITTING WEAKENS THE HANDLE. HANDLES WEAKENED BY CORROSION MAY BREAK WHILE TRYING TO OPEN THE DOOR FROM THE EXTERIOR.
CONSÉQUENCE
-
REMÈDE
DAIMLER TRUCKS WILL NOTIFY OWNERS AND WILL REPLACE THE HANDLES WITH A MORE ROBUST HANDLE FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY THOMAS BUILT BUSES DEALERSHIPS. THE RECALL BEGAN ON AUGUST 18, 2008, AND NOTIFICATION FOR THE REVISED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT APRIL 29, 2009. OWNERS MAY CONTACT THOMAS BUILT AT 336-889-4871.
REMARQUES
DAIMLER TRUCKS RECALL NO. FL-525. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
RÉSUMÉ
DAIMLER TRUCKS IS RECALLING 3,773 MY 1996 THROUGH 2002 THOMAS BUILT MVP ER SCHOOL BUSES MANUFACTURED FROM JUNE 8, 1995 THROUGH FEBRUARY 16, 2001, EQUIPPED WITH CATERPILLAR 3116 AND 3126 ENGINES. UN-FUSED POWER CABLES WERE TIE-WRAPPED TO A WIRE BRAID ENGINE FUEL RETURN HOSE. OVER TIME THESE CABLES MAY CHAFE, WEARING THROUGH THE WIRE LOOM AND EVENTUALLY THROUGH THE CABLE INSULATION AND FUEL LINE COVERING IN AN AREA NOT EASILY DETECTABLE DURING NORMAL MAINTENANCE WITHOUT REMOVING THE TIE WRAPS AND OPENING THE WIRE LOOM. UN-FUSED AND UN-SWITCHED POWER CABLES WHICH WEAR THROUGH AND CONTACT THE FUEL LINE WIRE BRAID MAY SHORT CIRCUIT.
CONSÉQUENCE
-
REMÈDE
THOMAS BUILT WILL NOTIFY OWNERS AND INSPECT AND REPLACE THE CABLES AS NECESSARY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 28, 2008. OWNERS MAY CONTACT THOMAS BUILT AT 1-336-889-4871.
REMARQUES
DAIMLER TRUCKS' RECALL NO. FL-534. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
