2005 thomas built buses minotour
RÉSUMÉ
CERTAIN MY 2004-2007 THOMAS BUILT MINOTOUR, FS65, MVP-EF, AND HDX MODEL SCHOOL BUSES, MANUFACTURED BETWEEN JUNE 16 AND JULY 1, 2005, EQUIPPED WITH RICON WHEELCHAIR LIFTS. CRACKS IN THE LIFT ARMS MAY ALLOW THE MECHANISM TO TWIST DURING STOWAGE, PREVENTING CLOSURE OF THE SAFETY INTERLOCK SWITCHES.
CONSÉQUENCE
-
REMÈDE
RICON IS CONDUCTING THIS RECALL (PLEASE SEE 06E008000) AND WILL REPLACE THE TWO VERTICAL ARMS EVEN IF ONLY ONE ARM IS CRACKED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON MAY 30, 2006. OWNERS MAY CONTACT RICON CUSTOMER SUPPORT DEPT. AT 800-322-2884 OR OWNERS MAY CONTACT THOMAS BUS CUSTOMER SUPPORT OFFICE AT 336-889-4871.
REMARQUES
FREIGHTLINER RECALL NO. FL-473. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
RÉSUMÉ
CERTAIN MY 2004-2007 THOMAS BUILT MINOTOUR SCHOOL AND COMMERCIAL BUSES MANUFACTURED BETWEEN JULY 1, 2005, AND FEBRUARY 16, 2006. THE FLOOR STRUCTURE FOR THE WHEELCHAIR LIFT FAIL TO COMPLY WITH THE STRENGTH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES.
CONSÉQUENCE
-
REMÈDE
THOMAS BUILT WILL NOTIFY OWNERS AND REPAIR THE LIFTS BY ADDING REINFORCEMENT FREE OF CHARGE. THE RECALL BEGAN ON JUNE 30, 2006. CUSTOMERS MAY CONTACT THOMAS BUS CUSTOMER SUPPORT OFFICE AT 336-889-4871.
REMARQUES
FREIGHTLINER RECALL NO. FL-474. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
RÉSUMÉ
CERTAIN MODEL YEAR 2000 THROUGH 2009 THOMAS BUILT SCHOOL BUSES MANUFACTURED FROM APRIL 17, 2000, THROUGH DECEMBER 21, 2009, WERE EQUIPPED WITH AN INCORRECT TIRE LOAD CERTIFICATION LABEL. THE CERTIFICATION LABELS LIST "D" LOAD RANGE TIRES WITH A RECOMMENDED COLD TIRE INFLATION PRESSURE GREATER THAN 65 PSI. THE BUSES ARE EQUIPPED WITH LOAD RANGE "E" TIRES THAT REQUIRE A HIGHER MINIMUM TIRE PRESSURE. ACCORDINGLY, THESE BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
CONSÉQUENCE
-
REMÈDE
DTNA WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE INCORRECT LABEL WITH A CORRECT LABEL FREE OF CHARGE OR, IF THE OWNER WISHES, THEY MAY REPLACE THE LABEL THEMSELVES. OWNERS SHOULD CONTACT DTNA AT 1-800-547-0712 OR THOMAS BUILT AT 1-336-889-4871 TO OBTAIN THE LABEL IF THEY WISH TO AFFIX IT THEMSELVES. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT MAY 28, 2011.
REMARQUES
DTNA'S RECALL CAMPAIGN NUMBER IS FL-601.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
RÉSUMÉ
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2010 MINOTOUR NON SCHOOL BUSES BUILT ON FORD CHASSIS MANUFACTURED FROM MAY 6, 2004 THROUGH FEBRUARY 2, 2010. ON AFFECTED VEHICLES, MAIN BODY POWER CABLES WERE ROUTED IN THE AREA OF AN UNPROTECTED EDGE ON THE PASSENGER'S SIDE INNER-FENDER. UNDER CERTAIN CONDITIONS A POWER CABLE MAY CONTACT THE SHARP EDGE. IF UNDETECTED, CONTINUED CONTACT COULD WEAR THROUGH THE POWER CABLE'S INSULATION POTENTIALLY RESULTING IN A SHORT CIRCUIT.
CONSÉQUENCE
-
REMÈDE
DAIMLER TRUCKS WILL INSPECT AND REROUTE AND/OR REPLACE AS NEEDED. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE NOVEMBER 15, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.
REMARQUES
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
RÉSUMÉ
CERTAIN MODEL YEAR 2000-2003, 2005 AND 2006 THOMAS BUILT MINOTOUR SCHOOL BUSES BUILT ON FORD AND GM CHASSIS FROM APRIL 17, 2000, THROUGH AUGUST 29, 2008. THESE BUSES WERE EQUIPPED WITH AN INCORRECT TIRE LOAD CERTIFICATION LABEL. THE CERTIFICATION LABELS LIST "D" LOAD RANGE TIRES WITH A RECOMMENDED COLD TIRE INFLATION PRESSURE GREATER THAN 65 PSI. THE BUSES ARE EQUIPPED WITH LOAD RANGE "E" TIRES THAT REQUIRE A HIGHER MINIMUM TIRE PRESSURE. ACCORDINGLY, THESE BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
CONSÉQUENCE
-
REMÈDE
DTNA WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE INCORRECT LABEL WITH A CORRECT LABEL FREE OF CHARGE OR, IF THE OWNER WISHES, THEY MAY REPLACE THE LABEL THEMSELVES. OWNERS SHOULD CONTACT DTNA AT 1-800-547-0712 OR THOMAS BUILT AT 1-336-889-4871 TO OBTAIN THE LABEL IF THEY WISH TO AFFIX IT THEMSELVES. THE SAFETY RECALL BEGAN ON MAY 24, 2011.
REMARQUES
DAIMLER TRUCKS' RECALL CAMPAIGN NUMBER IS FL-602.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
RÉSUMÉ
CERTAIN MODEL YEAR 2000, 2002 THROUGH 2006, AND 2009 THOMAS BUILT MINOTOUR NON SCHOOL BUSES MANUFACTURED FROM APRIL 17, 2000, THROUGH JANUARY 5, 2001, WERE EQUIPPED WITH AN INCORRECT TIRE LOAD CERTIFICATION LABEL. THE CERTIFICATION LABELS LIST "D" LOAD RANGE TIRES WITH A RECOMMENDED COLD TIRE INFLATION PRESSURE GREATER THAN 65 PSI. THE BUSES ARE EQUIPPED WITH LOAD RANGE "E" TIRES THAT REQUIRE A HIGHER MINIMUM TIRE PRESSURE. ACCORDINGLY, THESE BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
CONSÉQUENCE
-
REMÈDE
DTNA WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE INCORRECT LABEL WITH A CORRECT LABEL FREE OF CHARGE OR, IF THE OWNER WISHES, THEY MAY REPLACE THE LABEL THEMSELVES. OWNERS SHOULD CONTACT DTNA AT 1-800-547-0712 OR THOMAS BUILT AT 1-336-889-4871 TO OBTAIN THE LABEL IF THEY WISH TO AFFIX IT THEMSELVES. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT MAY 28, 2011.
REMARQUES
DAIMLER TRUCKS' RECALL CAMPAIGN NUMBER IS FL-601.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
RÉSUMÉ
DAIMLER TRUCKS IS RECALLING 216 MODEL YEAR 2004 THROUGH 2009 THOMAS BUILT MINOTOUR SCHOOL BUSES MANUFACTURED FROM FEBRUARY 5, 2003 THROUGH JULY 3, 2008. VEHICLES WITH CERTAIN SEAT BACK AND WINDOW COMBINATIONS MAY BE CONFIGURED IN SUCH A WAY THAT THE EMERGENCY WINDOW RELEASE MECHANISM IS LOCATED OUTSIDE OF THE LOW-FORCE REGION WHICH FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXISTS AND WINDOW RETENTION AND RELEASE."
CONSÉQUENCE
-
REMÈDE
DAIMLER TRUCKS WILL NOTIFY OWNERS AND REPAIR THE BUSES FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY DAIMLER TRUCKS NORTH AMERICA. THE SAFETY RECALL BEGAN ON NOVEMBER 17, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS CUSTOMER SUPPORT OFFICE AT 1-336-889-4871.
REMARQUES
DAIMLER TRUCKS RECALL CAMPAIGN NO. FL-552. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
RÉSUMÉ
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2010 SCHOOL BUSES BUILT ON FORD CHASSIS MANUFACTURED FROM MAY 6, 2004 THROUGH FEBRUARY 2, 2010. ON AFFECTED VEHICLES, MAIN BODY POWER CABLES WERE ROUTED IN THE AREA OF AN UNPROTECTED EDGE ON THE PASSENGER'S SIDE INNER-FENDER. UNDER CERTAIN CONDITIONS A POWER CABLE MAY CONTACT THE SHARP EDGE. IF UNDETECTED, CONTINUED CONTACT COULD WEAR THROUGH THE POWER CABLE'S INSULATION POTENTIALLY RESULTING IN A SHORT CIRCUIT.
CONSÉQUENCE
-
REMÈDE
DAIMLER TRUCKS WILL INSPECT AND REROUTE AND/OR REPLACE AS NEEDED. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE NOVEMBER 15, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.
REMARQUES
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
RÉSUMÉ
DAIMLER TRUCKS NORTH AMERICA (DTNA) IS RECALLING 2,590 MY 2005 THROUGH 2009 THOMAS BUILT MINOTOUR SCHOOL BUSES WITH GVWR OF 10,000 POUNDS OR LESS, MANUFACTURED BETWEEN SEPTEMBER 1, 2004 AND NOVEMBER 26, 2008. THE TIRE PLACARD CONTAINS INCORRECT INFORMATION WHICH FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, TIRE SELECTION AND RIMS.
CONSÉQUENCE
-
REMÈDE
NEW LABELS WILL BE SENT TO OWNERS FOR INSTALLATION. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 3, 2009. OWNERS MAY CONTACT DTNA AT 1-800-547-0712 OR THOMAS BUILT AT 1-336-889-4871.
REMARQUES
DTNA'S RECALL NO. FL-540. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
RÉSUMÉ
DAIMLER TRUCKS IS RECALLING 760 MY 2003-2007 THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 6, 2005 AND JULY 19, 2006, EQUIPPED WITH BRAUN WHEELCHAIR LIFTS, MODELS NL, NCL, OR NVL. THE THRESHOLD WARNING SYSTEMS OF THE SUBJECT MODEL WHEELCHAIR LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES.
CONSÉQUENCE
-
REMÈDE
DAIMLER TRUCKS WILL NOTIFY OWNERS AND PROVIDE A FREE REMEDY WHICH WILL BE PERFORMED BY THOMAS BUILT DEALERSHIPS. THE RECALL BEGAN ON AUGUST 8, 2008. OWNERS MAY CONTACT THOMAS BUILT AT 336-889-4871.
REMARQUES
DAIMLER TRUCKS RECALL NO. FL-524. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
RÉSUMÉ
Daimler Trucks North America LLC (DTNA) is recalling certain 2002-2017 Thomas Built Buses Saf-T-Liner C2, Saf-T-Liner HDX, FS65, and Minotour school buses, equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
CONSÉQUENCE
-
REMÈDE
DTNA will notify owners instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall is expected to begin March 30, 2018. Owners may contact DTNA customer service at 1-800-547-0712 or Kidde customer service at 1-855-262-3540 or online at www.kidde.com and click on "Product Safety Recall" for more information. DTNA's number for this recall is FL-759.
REMARQUES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
RÉSUMÉ
Daimler Trucks North America LLC (DTNA) is recalling certain 2003-2019 Thomas Built Buses Minotour school buses built on a Ford chassis equipped with a specific wheelchair lift option. The wheelchair lift can be operated without the parking brake being engaged after they key is turned off.
CONSÉQUENCE
-
REMÈDE
DTNA has notified owners, and dealers will modify the wheelchair lift wiring harness, free of charge. DTNA issued owners an interim notification on April 10, 2019. The recall began December 20, 2019. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-811.
REMARQUES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
RÉSUMÉ
Daimler Trucks North America LLC (DTNA) is recalling certain 2003-2006 Thomas Built Buses Minotour transit buses built on a Ford chassis and equipped with an optional wheelchair lift. The wheelchair lift may be allowed to operate when the vehicle is in neutral or drive, due to missing relay in the interlock wiring harness.
CONSÉQUENCE
-
REMÈDE
DTNA will notify owners, and dealers will inspect the wheelchair lift wiring, correcting it as necessary, free of charge. Daimler issued an interim notification to owners on June 19, 2018. The recall began November 15, 2019. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-770.
REMARQUES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
RÉSUMÉ
Daimler Trucks North America LLC (DTNA) is recalling certain 2002-2018 Thomas Built Buses Minotour school buses built on a Ford chassis and equipped with an optional wheelchair lift. The wheelchair lift may be allowed to operate when the vehicle is in neutral or drive, due to missing relay in the interlock wiring harness.
CONSÉQUENCE
-
REMÈDE
DTNA will notify owners, and dealers will inspect the wheelchair lift wiring, correcting it as necessary, free of charge. Daimler issued an interim notification to owners on June 19, 2018. The recall began November 15, 2019. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-770.
REMARQUES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
