2004 newmar kountry star
RÉSUMÉ
CERTAIN SEAT BELT BUCKLES ON SOME MOTOR HOMES FAIL TO CONFORM TO THE LOAD REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
CONSÉQUENCE
-
REMÈDE
AMSAFE WILL NOTIFY CUSTOMERS AND REPLACE THE BUCKLES. THE RECALL BEGAN MAY 28, 2004. OWNERS SHOULD CONTACT AMSAFE AT 1-574-266-8330 OR NEWMAR AT 1-574-773-7791.
REMARQUES
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
RÉSUMÉ
ON CERTAIN MOTOR HOMES EQUIPPED WITH AMETEK NGI GAUGES, THE AIR GAUGES ARE NOT PROPERLY CALIBRATED AND THE LOW AIR WARNING INDICATOR MAY BE ACTIVATED WHEN ACTUAL AIR RESERVOIR PRESSURE READINGS ARE BELOW THE FEDERAL MOTOR VEHICLE SAFETY STANDARD REQUIRED RANGE OF 60 TO 65PSI.
CONSÉQUENCE
-
REMÈDE
SPARTAN IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSTALL A HARNESS JUMPER CABLE TO EACH AIR SENDER. OWNERS MAY CONTACT SPARTAN AT 800-543-4277 OR NEWMAR AT 574-773-7719.
REMARQUES
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
RÉSUMÉ
CERTAIN CLASS A MOTOR HOMES BUILT ON WORKHORSE CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 101, "CONTROLS AND DISPLAY" AND STANDARD NO. 105 "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." MODELS WITH ACTIA INSTRUMENT CLUSTER, THE INCORRECT SOFTWARE PROGRAMMED INTO THE CLUSTER SUCH THAT CERTAIN WARNINGS ARE NOT DISPLAYED.
CONSÉQUENCE
-
REMÈDE
WORKHORSE IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. OWNERS MAY CONTACT WORKHORSE AT 1-877-294-6773 OR NEWMAR AT 574-773-7719.
REMARQUES
WORKHORSE RECALL NO. 50402-C. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
RÉSUMÉ
ON CERTAIN MOTORHOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH BOSCH ZOPS BRAKE CALIPERS, THE PADS CAN DRAG ON THE ROTOR SURFACE DUE TO THE PIN SLIDE.
CONSÉQUENCE
-
REMÈDE
WORKHORSE IS NOTIFYING CUSTOMERS AND WILL ARRANGE TO HAVE THE CALIPERS AND BRAKE PADS REPLACED ON THE AFFECTED VEHICLES. OWNERS SHOULD CONTACT WORKHORSE AT 1-877-294-6773 OR NEWMAR AT 1-574-773-5153.
REMARQUES
CUSTOMER'S CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
RÉSUMÉ
ON CERTAIN MOTOR HOMES, DURING MANUFACTURING, THE SEAT BELT SHOULDER HARNESS ATTACHMENT LOCATION FOR THE PASSENGER SEAT WAS NOT PROPERLY WELDED OR ATTACHED.
CONSÉQUENCE
-
REMÈDE
DEALERS WILL INSTALL A NEW PLATE OVER EXISTING BY DRILLING FOUR ATTACHMENT HOLES ON EACH SIDE OF NEW PLATE AND ADD SECURING BOLTS. THIS RECALL BEGAN OCTOBER 1, 2004. OWNERS MAY CONTACT NEWMAR AT 1-574-773-7791.
REMARQUES
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
RÉSUMÉ
NEWMAR IS RECALLING CERTAIN RECREATIONAL TRAILERS EQUIPPED WITH DIMPLEX ELECTRAFLAME, SYMPHONY, OR OPTIFLAME BRANDED ELECTRIC FIREPLACES, STOVES, AND FIREPLACE INSERTS. THE PLUG IN REMOTE CONTROL RECEIVER FOR THE FIREPLACE CAN OVERHEAT.
CONSÉQUENCE
-
REMÈDE
NEWMAR IS WORKING WITH DIMPLEX AND DIMPLEX WILL PROVIDE OWNERS A FREE REPLACEMENT PLUG-IN REMOTE CONTROL KIT. THE SAFETY RECALL BEGAN ON APRIL 6, 2011. OWNERS MAY CONTACT DIMPLEX NORTH AMERICA CUSTOMER SERVICE AT 1-888-346-7539.
REMARQUES
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
RÉSUMÉ
NEWMAR IS RECALLING 772 MY 2004-2005 AMERICAN STAR, KOUNTRY AIRE, MOUNTAIN AIRE, MY 2003-2006 KOUNTRY STAR, MY 2007 X-AIRE FIFTH WHEEL TRAILERS; MY 2007 BAY STAR, MY 2004-2007 KOUNTRY STAR, MY 2004-2006 MOUNTAIN AIRE, MY 2003-2005 SCOTTSDALE CLASS A MOTOR HOMES; AND MY 2004-2006 DUTCH STAR, MY 2003-2006 KOUNTRY STAR, MY 2004-2006 MOUNTAIN AIRE DIESEL PUSHER MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
CONSÉQUENCE
-
REMÈDE
NEWMAR IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR NEWMAR AT 1-574-773-7791.
REMARQUES
CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
RÉSUMÉ
NEWMAR IS RECALLING 2,578 MOTORHOMES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.
CONSÉQUENCE
-
REMÈDE
DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS FREE OF CHARGE. WORKHORSE IS HANDLING THE REMEDY AND OWNER NOTIFICATION FOR THIS CAMPAIGN PLEASE SEE 09V-110. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731.
REMARQUES
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
RÉSUMÉ
Newmar Corporation (Newmar) is recalling various 1995-2018 motorhomes. A list of the affected vehicles available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V809-2309.pdf. These motorhomes are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
CONSÉQUENCE
-
REMÈDE
Newmar will notify owners, and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on February 7, 2018. Owners may contact Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information or owners may contact Newmar customer service at 1-574-773-7791. Newmar's number for this recall is 17E-062.
REMARQUES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
