2024 Gillig Low Floor
RÉSUMÉ
Gillig, LLC (Gillig) is recalling certain 2023-2024 Low Floor transit buses. The steering spline shaft fasteners may have been improperly tightened, allowing the steering spline shaft to loosen.
CONSÉQUENCE
-
REMÈDE
Gillig will tighten the fasteners, free of charge. Owner notification letters were mailed August 13, 2024. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.
REMARQUES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
RÉSUMÉ
Gillig, LLC (Gillig) is recalling certain 2024 Low Floor buses. A defective welded joint may cause the wiper arm to suddenly fail. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 104, "Windshield Wiping and Washing Systems."
CONSÉQUENCE
-
REMÈDE
Gillig will replace the wiper motor arm, free of charge. Owner notification letters were mailed December 12, 2024. Owners may contact Gillig customer service at 1-800-735-1500.
REMARQUES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153) or go to nhtsa.gov.
RÉSUMÉ
Gillig, LLC (Gillig) is recalling certain 2021-2024 Low Floor style transit buses. The fire suppression relay cable may be damaged, chafing against the mounting bolt, and fail.
CONSÉQUENCE
-
REMÈDE
Dealers will replace the relay cable, free of charge. Owner notification letters were mailed December 31, 2024. Owners may contact GILLIG customer service at 1-800-735-1500.
REMARQUES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153) or go to nhtsa.gov.
RÉSUMÉ
Gillig, LLC (Gillig) is recalling certain 2023-2024 Low Floor style transit buses. The high voltage electric air compressor may not be connected to the High Voltage Interlock Loop (HVIL). Therefore, the HVIL cannot detect a loose or disconnected compressor power cable.
CONSÉQUENCE
-
REMÈDE
Dealers will install an additional electrical harness, extending the HVIL loop to the air compressor, free of charge. Owner notification letters were mailed February 12, 2025. Owners may contact GILLIG customer service at 1-800-735-1500.
REMARQUES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153) or go to nhtsa.gov.
RÉSUMÉ
Gillig, LLC (Gillig) is recalling certain 2019-2024 Low Floor transit buses. The rivet-nut fasteners that secure the TFT flat panel display monitor to the bus ceiling may fail, causing the monitor to detach and fall.
CONSÉQUENCE
-
REMÈDE
Gillig will replace the rivet-nut fasteners, free of charge. Owner notification letters were mailed March 18, 2025. Owners may contact Gillig customer service at 1-800-735-1500.
REMARQUES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153) or go to nhtsa.gov.
