2000 thomas mvp ef
RESUMEN
ON CERTAIN SCHOOL AND TRANSIT BUSES, THE WHEEL LUG NUT MAY NOT TIGHTEN COMPLETELY.
CONSECUENCIA
-
REMEDIO
DEALERS WILL INSTALL NEW WHEEL STUDS. OWNER NOTIFICATION BEGAN FEBRUARY 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 336-889-4871.
NOTA
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
RESUMEN
VEHICLE DESCRIPTION: CERTAIN SCHOOL BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE." A THIRD ROOF HATCH MUST BE ADDED TO MEET THE STANDARD REQUIREMENTS. ONLY VEHICLES LOCATED IN THE STATE OF WASHINGTON ARE INVOLVED.
CONSECUENCIA
-
REMEDIO
DEALERS WILL INSTALL A THIRD ROOF HATCH. OWNER NOTIFICATION BEGAN MAY 1, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 336-889-4871.
NOTA
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
RESUMEN
VEHICLE DESCRIPTION: SCHOOL AND TRANSIT BUSES EQUIPPED WITH SAFETY BELT ASSEMBLIES PRODUCED BY AM-SAFE. ON SOME SEAT BELTS, THE BUCKLE AND CONNECTOR MAY UNLATCH DURING A COLLISION.
CONSECUENCIA
-
REMEDIO
AM-SAFE NOTIFIED THOMAS BUILT'S CUSTOMERS TO RETURN THEIR VEHICLE TO AN AUTHORIZED DEALER TO HAVE THE SEAT BELTS REPAIRED FREE OF CHARGE. OWNER NOTIFICATION BEGAN SEPTEMBER 21, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 1-336-889-4871.
NOTA
ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
RESUMEN
VEHICLE DESCRIPTION: SCHOOL BUS CHASSIS AND EMERGENCY VEHICLES BUILT WITH BENDIX AIR ABS WITH AN EC-17 1030R ELECTRONIC CONTROL UNIT (ECU), THERE HAVE BEEN REPORTS OF UNWANTED ABS ACTIVATION AT LOW SPEEDS CAUSED BY 1) CHAFED ABS WHEEL SPEED SENSOR WIRES ON ROTATING PARTS OR 2) A DAMAGED COMPONENT AT THE WHEEL END THAT GENERATES A CERTAIN TYPE OF ERRATIC SENSOR SIGNAL.
CONSECUENCIA
-
REMEDIO
DEALERS WILL REPLACE THE ABS ECU.
NOTA
OWNER NOTIFICATION BEGAN AUGUST 29, 2000, TO SCHOOL BUSES AND EMERGENCY VEHICLE CUSTOMERS. OWNERS OF THE REMAINING POPULATION WERE SENT LETTERS ON SEPTEMBER 9, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
RESUMEN
VEHICLE DESCRIPTION: CERTAIN SCHOOL BUSES AND TRANSIT BUSES EQUIPPED WITH NATIONAL SEATING'S SERIES 93B-SB DRIVER SEAT. A BRACKET ATTACHING THE GAS SPRING SHOCK TO THE HEIGHT ADJUSTER OF THE SEAT CAN DEFORM AND BREAK. THIS BRACKET IS LOCATED AT THE TOP OF THE HEIGHT ADJUSTER.
CONSECUENCIA
-
REMEDIO
DEALERS WILL REPLACE THE SEAT BASE AND ADD REINFORCEMENT TO THE SEAT ASSEMBLY
NOTA
OWNER NOTIFICATION BEGAN FEBRUARY 9, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
RESUMEN
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS AND SCHOOL BUS CHASSIS BUILT WITH BENDIX AIR ABS WITH AN EC-17 1030R ELECTRONIC CONTROL UNIT (ECU), THERE HAVE BEEN REPORTS OF UNWANTED ABS ACTIVATION AT LOW SPEEDS CAUSED BY 1) CHAFED ABS WHEEL SPEED SENSOR WIRES ON ROTATING PARTS OR 2) A DAMAGED COMPONENT AT THE WHEEL END THAT GENERATES A CERTAIN TYPE OF ERRATIC SENSOR SIGNAL.
CONSECUENCIA
-
REMEDIO
DEALERS WILL REPLACE THE ABS ECU.
NOTA
OWNER NOTIFICATION BEGAN AUGUST 29, 2000, TO SCHOOL BUSES AND EMERGENCY VEHICLE CUSTOMERS. OWNERS OF THE REMAINING POPULATION WERE SENT LETTERS ON SEPTEMBER 9, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
RESUMEN
VEHICLE DESCRIPTION: SCHOOL AND TRANSIT BUSES EQUIPPED WITH AIR BRAKES AND A TRW STEERING GEAR. THE PINCH BOLT ON THE PITMAN ARM CONTACTS THE EXHAUST PORT ON THE AIR BRAKE TREADLE VALVE DURING STEERING MANEUVERS.
CONSECUENCIA
-
REMEDIO
DEALERS WILL ADD A SPACER UNDER THE BRAKE VALVE TO PROVIDE SUFFICIENT CLEARANCE.
NOTA
OWNER NOTIFICATION BEGAN AUGUST 16, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 1-336-881-7219. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
RESUMEN
CERTAIN 1998-2003 MY FREIGHTLINER FS-65 SCHOOL BUS CHASSIS AND MB-45, MB-55, AND XB SHUTTLE BUS CHASSIS, AND THOMAS BUILT BUS: MVP-ER AND MVP-EF SCHOOL BUS AND NON-SCHOOL BUS MODELS EQUIPPED WITH CUMMINS ISB DIESEL ENGINES AND EQUIPPED WITH FEDERAL-MOGAL 12 AND 24 VOLT FUEL LIFT PUMPS. THE FUEL PUMP COULD FAIL TO TRANSFER FUEL APPROPRIATELY CREATING AN ENGINE STALL CONDITION.
CONSECUENCIA
-
REMEDIO
CUMMINS WILL NOTIFY THE CUSTOMERS OF FREIGHTLINER AND THOMAS BUILT AND REPLACE THE FUEL LIFT PUMP FREE OF CHARGE. OWNERS MAY CONTACT CUMMINS AT 1-800-DIESELS.
NOTA
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
RESUMEN
CERTAIN MY 1994 THROUGH 2002 THOMAS BUILT MINOTOUR, FS-65, MVP-EF, ER, AND HDX-EF SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 23, 1994, AND APRIL 15, 2002. THE SEAT BELT MAY CHAFE ON THE EDGE OF A METAL BRACKET AND WEAR PREMATURELY.
CONSECUENCIA
-
REMEDIO
THOMAS BUILT WILL NOTIFY OWNERS AND REPLACE ANY CHAFED SEAT BELTS AND REPLACE OR MODIFY THE RETAINER STRIP TO PREVENT ANY FURTHER CHAFING. THE RECALL BEGAN ON FEBRUARY 8, 2008. OWNERS MAY CONTACT THOMAS BUILT AT 336-889-4871 OR CONTACT FREIGHTLINER AT 800-547-0712.
NOTA
FREIGHTLINER RECALL NO. FL-495. CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.
RESUMEN
ON CERTAIN SCHOOL OR TRANSIT BUSES WITH PASSENGER SEAT BELTS WITH RETRACTORS, THE COVER HALVES FOR THE RETRACTABLE PORTION OF THE BELT CAN SEPARATE COMPLETELY AND RELEASE THE SEAT BELT CONNECTOR. IF THIS OCCURS, ONE OF THE LOAD BEARING PINS IN THE CONNECTOR COULD SEPARATE FROM THE CONNECTOR AND RENDER THE SEAT BELT UNUSABLE. IN THE EVENT OF A CRASH, THE SEAT OCCUPANT WOULD NOT BE PROPERLY RESTRAINED RESULTING IN AN INJURY. THE SEAT BELT SUPPLIER, AMSAFE, WILL PROVIDE A SNAP ON "OVER-COVER" TO OWNERS TO PREVENT THE SEAT BELT COVER FROM SEPARATING.
CONSECUENCIA
-
REMEDIO
DEALERS WILL PROVIDE A PLASTIC OUTER COVER THAT SNAPS OVER THE EXISTING COVER ON UNITS IN THE FIELD AND WILL REPLACE BROKEN SEAT BELTS FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 336-841-5924 OR AMSAFE AT 574-266-8330.
NOTA
ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
RESUMEN
ON CERTAIN THOMAS SCHOOL BUSES, THE ALTERNATOR CABLE CAN PINCH BETWEEN THE AIR CONDITIONING COMPRESSOR AND ENGINE BLOCK.
CONSECUENCIA
-
REMEDIO
DEALERS WILL RE-ROUTE THE CABLE. OWNER NOTIFICATION BEGAN JULY 28, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER/THOMAS BUILT AT
NOTA
FREIGHTLINER/THOMAS BUILT RECALL NO. FL-415. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
