2005 mci d4500
ملخص
ON CERTAIN MOTOR COACHES EQUIPPED WITH DETROIT DIESEL SERIES 60 ENGINES, THE TURBOCHARGER COMPRESSORS CAN FAIL.
نتيجة
-
إصلاح
DETROIT DIESEL IS CONDUCTING THIS RECALL (PLEASE SEE 06E019000) AND WILL REMEDY THESE MOTOR COACHES. THE ENGINES WILL BE REPAIRED FREE OF CHARGE. OWNERS MAY CONTACT DETROIT DIESEL AT 313-592-3708 OR MOTOR COACH AT 866-624-2622.
ملاحظات
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
ملخص
ON CERTAIN D SERIES MOTOR COACHES, THERE COULD BE A POSSIBLE INTERFERENCE BETWEEN THE DRIVE SHAFT MOUNTING HARDWARE AND THE TAG AXLE STRUCTURE.
نتيجة
-
إصلاح
SHIMS WILL BE INSTALLED ABOVE THE TAG AXLE AIR SPRING MOUNTING BRACKETS TO LIMIT THE SUSPENSION TRAVEL. THE RECALL IS EXPECTED TO BEGIN DURING JANUARY 2007. OWNERS MAY CONTACT MCI AT 1-800-241-2947.
ملاحظات
MCI RECALL NO. 276 & 277. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
ملخص
ON CERTAIN MOTOR COACHES, THE BOOST CONNECTOR HOUSING CAN FAIL OVER TIME, EXPOSING THE POSITIVE AND NEGATIVE TERMINALS.
نتيجة
-
إصلاح
CUSTOMERS ARE BEING ADVISED TO REMOVE THE BOOST CONNECTOR AND DISCARD IT. CUSTOMERS WILL BE OFFERED A NEW DESIGN BOOST CONNECTOR AS AN ALTERNATIVE AT NO COST. THE RECALL BEGAN ON JANUARY 2, 2007. OWNERS MAY CONTACT MCI AT 1-800-241-2947.
ملاحظات
MCI RECALL NO. 274. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
ملخص
ON CERTAIN MOTOR COACHES EQUIPPED WITH A SLIDE SWITCH TO CONTROL THE DEFROSTER BLOWER SPEED, THERE IS A SPEED CONTROLLER FOR EACH OF THE TWO DEFROSTER FAN MOTORS. THE SPEED CONTROLLER MAY FAIL CAUSING THE FAN MOTOR TO OPERATE CONTINUOUSLY IN THE "HIGH" SPEED MODE, AND THE CARRIER SLIDE SWITCH MAY FAIL TO REDUCE OR OTHERWISE CONTROL THE FAN MOTOR SPEED.
نتيجة
-
إصلاح
DEALERS WILL REPLACE THE DEFROSTER SPEED CONTROLLER FREE OF CHARGE. THE RECALL BEGAN ON JULY 20, 2006. OWNERS MAY CONTACT MOTOR COACH AT 1-800-241-2947.
ملاحظات
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
ملخص
MCI IS RECALLING CERTAIN MODEL YEAR 2002-2009 D SERIES COACHES, EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR.
نتيجة
-
إصلاح
MCI WILL NOTIFY OWNERS AND LUMINATOR WILL REPAIR THE BUSES FREE OF CHARGE. PLEASE SEE LUMINATOR'S DEFECT REPORT 09E-054. THE SAFETY RECALL BEGAN ON NOVEMBER 9, 2009. OWNERS MAY CONTACT LUMINATOR AT 1-972-516-3033 OR MCI CUSTOMER SERVICE AT 1-800-241-2947.
ملاحظات
MCI RECALL NO. 335. OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
ملخص
MCI IS RECALLING CERTAIN MODEL YEAR 2005-2008 D4000, MODEL YEAR 2005-2009 D4500 AND D4505 TRANSIT BUSES, EQUIPPED WITH CATERPILLAR C13 ENGINE AND 50DN ALTERNATOR. THE ALTERNATOR CABLE MAY BECOME LOOSE WITHIN THE CABLE CLAMP, WHICH COULD RESULT IN CHAFING OF THE ALTERNATOR CABLE AND POSSIBLE ARCING OF THE CABLE WIRES.
نتيجة
-
إصلاح
MCI WILL NOTIFY OWNERS AND REPLACE THE ALTERNATOR CABLE CLAMP AND RELATED HARDWARE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 30, 2009. OWNERS MAY CONTACT MCI CUSTOMER SERVICE AT 1-800-241-2947.
ملاحظات
OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
ملخص
MCI IS RECALLING 103 MY 2005-2008 D4500 AND D4505 COACHES EQUIPPED WITH DETROIT DIESEL SERIES 60 ENGINES AND A ZF TRANSMISSION. CUSTOMERS MAY EXPERIENCE A POSSIBLE INTERFERENCE BETWEEN THE DRIVE SHAFT U-JOINT BEARING CAP BOLTS AND THE TAG AXLE CENTER BEAM ASSEMBLY.
نتيجة
-
إصلاح
DEALERS WILL INSTALL A TAG AXLE SUSPENSION SPACER KIT AND AN SPL250 DRIVESHAFT RETROFIT KIT TO LIMIT THE SUSPENSION TRAVEL AND REDUCE THE SWING DIAMETER OF THE DRIVESHAFT THEREBY INCREASING THE CLEARANCE AND ELIMINATING ANY POSSIBLE INTERFERENCE. THE RECALL BEGAN ON FEBRUARY 25, 2009. OWNERS MAY CONTACT MCI AT 1800-241-2947.
ملاحظات
CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
ملخص
MCI IS RECALLING CERTAIN MODEL YEAR 2000-2009 D4000, MODEL YEAR 2001-2010 D4500 AND MODEL YEAR 2005-2007 D4505 COACHES EQUIPPED WITH RICON WHEELCHAIR LIFT (WCL) AND A CASSETTE-TYPE WCL COMPARTMENT DOOR. THE WHEELCHAIR LIFT MAY BECOME DISENGAGED FROM A LOCKED POSITION AND SLIDE UNRESTRAINED ON ITS ROLLERS IN THE STORAGE STRUCTURE, POTENTIALLY BREAKING THROUGH THE CASSETTE DOOR AND EXTENDING BEYOND THE OUTSIDE OF THE DOOR WHEN THE COACH IS IN MOTION, PARTICULARLY WHEN THE COACH IS MAKING A LEFT TURN.
نتيجة
-
إصلاح
MCI WILL PROVIDE PARTS AND LABOR TO INSTALL FREE OF CHARGE TO CUSTOMERS, A RICON DESIGNED RETROFIT KIT THAT INCLUDES A SPRING LOADED LOCK MECHANISM. THE SAFETY RECALL BEGAN ON MARCH 31, 2010. OWNERS MAY CONTACT MCI CUSTOMER SERVICE LINE AT 1-800-241-2947.
ملاحظات
MCI RECALL NO. 341.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .
ملخص
Motor Coach Industries (MCI) is recalling certain model year 2000-2012 D, E, G and J series coaches manufactured January 2000 through June 2011 and equipped with Sure Power battery equalizers containing a particular epoxy sealing, aka 'potting', compound. The specific potting compound used in the subject products for insulation was found to be capable of conducting electricity after being exposed to heat.
نتيجة
-
إصلاح
MCI will notify owners, and Sure Power will replace the equalizers, free of charge. Owners may contact MCI at 1-847-285-2000. This campaign is MCI service bulletin 401.
ملاحظات
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
