ClearVin Free Recalls Check by Make and Model
Below are all the recalls for a specific make and model for the indicated year. This gives you all recalls related to this model and the details of each recall.
2016 autocar xpeditor
SUMMARY
Autocar, LLC (Autocar) is recalling certain model year 2015-2016 Xpeditor vehicles manufactured November 18, 2014, to July 6, 2015. The affected vehicles are equipped with heating, ventilation and air conditioning (HVAC) units whose defrost mode door actuators may overheat.
CONSEQUENCE
No Data
REMEDY
Autocar will notify owners, and dealers will install an additional harness with four, one amp fuses to the circuit, free of charge. The recall began on September 3, 2015. Owners may contact Autocar customer service at 1-765-489-5499. Autocar's number for this recall is ACX-1504.
NOTES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
SUMMARY
Autocar, LLC (Autocar) is recalling certain model year 2016-2017 Xpeditor vehicles manufactured March 04, 2016, through April 21, 2016. The tab lock washers on the rear axle wheel ends may not have been properly bent over the outer spindle nut during assembly.
CONSEQUENCE
No Data
REMEDY
Autocar will notify owners and dealers will inspect the tab lock washers and remedy tabs where needed, free of charge. The recall began on June 30, 2016. Owners may contact Autocar's customer service at 1-765-489-5499. Autocar's number for this recall is ACX-1602.
NOTES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
SUMMARY
Autocar, LLC (Autocar) is recalling certain model year 2008-2016 Xpeditor vehicles manufactured July 30, 2007, to April 29, 2015. Excessive engine crankcase pressures may cause the 90-degree elbow of the vent tube assembly to detach from the crankcase ventilation breather, possibly allowing engine oil to come into contact with hot surfaces.
CONSEQUENCE
No Data
REMEDY
Cummins will notify owners on behalf of Autocar, and Cummins service centers will administer the repairs which include securing the ends of the 90-degree elbow and reprogramming the electronic control module (ECM) with software that can adjust the engine output under misfire conditions to limit crankcase pressures. These repairs will be performed free of charge. The recall began on June 16, 2015. Owners may contact Autocar customer service at 1-765-489-5499 or Cummins Inc. at 1-800-343-7357. Autocar's number for this recall is ACX-1503.
NOTES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
SUMMARY
Autocar, LLC (Autocar) is recalling certain model year 2011-2016 Xpeditor vehicles manufactured October 12, 2010, to May 4, 2015. The affected vehicles have a synchronization valve with Autocar part number A7660006-001 and any of the following cab configurations where the park brake button (sometimes referred to as the park brake valve) is located to the right of the RH drive steering wheel: RH Drive, dual drive/dual sit, and dual drive/RH stand. If the operator inadvertently or erroneously attempts to release the park brake without first firmly applying the service brake, the park brake will subsequently engage, at any speed and likely unexpectedly to the operator.
CONSEQUENCE
No Data
REMEDY
Autocar will notify owners, and dealers will replace the synchronization valve with one that has a lower opening pressure, free of charge. The recall began on July 8, 2015. Owners may contact Autocar customer service at 1-765-489-5499. Autocar's number for this recall is ACX-1502.
NOTES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
SUMMARY
Autocar, LLC (Autocar) is recalling certain model year 2014-2016 Xpeditor vehicles manufactured January 3, 2014, to August 13, 2015. In dual-drive, right-hand stand configurations, the right-side brake plunger may stick and cause the brakes to drag.
CONSEQUENCE
No Data
REMEDY
Autocar will notify owners, and dealers will replace the brake plunger, free of charge. The recall began on December 4, 2015. Owners may contact Autocar customer service at 1-888-218-3611. Autocar's number for this recall is ACX-1505.
NOTES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
SUMMARY
Autocar, LLC (Autocar) is recalling certain model year 2016-2017 Xpeditor vehicles manufactured March 21, 2016, to April 11, 2016, equipped with a Cummins ISX12 or ISX15 engine using certain engine control modules (ECM). These ECM's may experience an internal electrical short that can cause a fuse to blow, resulting in an unexpected engine stall without the ability to restart the engine.
CONSEQUENCE
No Data
REMEDY
Cummins will notify owners, and Cummins dealers will replace the existing ECM with a new ECM, free of charge. The recall began on July 7, 2016. Owners may contact Cummins customer service at 1-800-343-7357 or Autocar customer service at 1-765-489-5499. Autocar's number for this recall is ACX-1603.
NOTES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
SUMMARY
Autocar, LLC (Autocar) is recalling certain model year 2013-2016 Xpeditor vehicles manufactured August 15, 2012, to January 5, 2016. The affected vehicles are configured with dual-drive, right-hand-stand-up cabs. In these vehicles, the locking cotter pin on the brake pedal mounting bracket may not be fully engaged, allowing the brake pedal to detach.
CONSEQUENCE
No Data
REMEDY
Autocar will notify owners, and dealers will correct the installation of, or install, the cotter pin, free of charge. The recall began on March 4, 2016. Owners may contact Autocar customer service at 1-765-489-5499. Autocar's number for this recall is ACX-1601.
NOTES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
SUMMARY
Autocar, LLC (Autocar) is recalling certain 2013-2016 Xpeditor vehicles equipped with auxiliary axles and 36/36 rear brake chambers. Over-braking can cause excessive vibration and cause the S-cam tube bolts to become loose and allow the brakes to unexpectedly engage.
CONSEQUENCE
No Data
REMEDY
Autocar will contact owners and dealers will change the rear brake chambers and the S-cam brackets, free of charge. The recall began on March 17, 2017. Owners may contact Autocar customer service at 1-765-489-5499. Autocar's number for this recall is ACX-1701.
NOTES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
SUMMARY
Autocar, LLC (Autocar) is recalling certain model year 2015-2017 Xpeditor vehicles manufactured March 2, 2015, to September 22, 2016. The castle nuts on the steering linkage assembly may not have been tightened properly.
CONSEQUENCE
No Data
REMEDY
Autocar will notify owners, and dealers will tighten the steering linkage castle nuts, as necessary, free of charge. The recall is expected to begin during November 2016. Owners may contact Autocar customer service at 1-888-218-3611. Autocar's number for this recall is ACX-1604.
NOTES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
SUMMARY
Autocar, LLC (Autocar) is recalling certain model year 2013-2017 Xpeditor vehicles manufactured December 10, 2012, to November 1, 2016. In the affected vehicles, fuse box vibration may cause the ignition relay to open resulting in an engine stall.
CONSEQUENCE
No Data
REMEDY
Autocar will notify owners, and dealers will install an additional bracket to lower the vibration of the fuse box, free of charge. The recall began on January 20, 2017. Owners may contact Autocar customer service at 1-765-489-5499. Autocar's number for this recall is ACX-1606.
NOTES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
SUMMARY
Autocar, LLC (Autocar) is recalling certain model year 2012-2016 Xpeditor vehicles manufactured September 6, 2011, to October 1, 2015. The affected vehicles have hybrid power drive unit cradle mounting bolts that may not have been properly tightened.
CONSEQUENCE
No Data
REMEDY
The remedy for this recall is still under development. The recall began January 13, 2017. Owners may contact Autocar customer service at 1-765-489-5499. Autocar's number is ACX-1605.
NOTES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
SUMMARY
Autocar, LLC (Autocar) is recalling certain 2014-2018 Xpeditor vehicles equipped with a factory installed methane detection system. The circuit protection for the methane detector may be inadequate, and the harness may be improperly routed.
CONSEQUENCE
No Data
REMEDY
Autocar will notify owners, and dealers will replace the ten amp fuse with a three amp fuse, free of charge. The recall began on April 13, 2018. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3486. Autocar's number for this recall is ACX-1801.
NOTES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
SUMMARY
Autocar, LLC (Autocar) is recalling certain 2008-2019 Xpeditor vehicles. The affected vehicles are equipped with undersized brake chambers, possibly allowing the truck to roll when parked. As a result, the vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air brake systems."
CONSEQUENCE
No Data
REMEDY
Autocar will notify owners, and dealers will replace the parking brake chambers with ones of the proper size, free of charge. The recall began April 16, 2019. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3486. Autocar's number for this recall is ACX-1903.
NOTES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
SUMMARY
Autocar, LLC (Autocar) is recalling certain 2017 Xpeditor vehicles, equipped with certain Dana Spicer D-Series and E-Series steer axles. The castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen.
CONSEQUENCE
No Data
REMEDY
Autocar will notify owners, and dealers will inspect the torque of the castellated nut and tie rod, tightening it as necessary, free of charge. The recall began on September 20, 2017. Owners may contact Autocar customer service at 1-888-218-3611. Autocar's number for this recall is ACX-1703.
NOTES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
SUMMARY
Autocar, LLC. (Autocar) is recalling certain 2014-2018 Xpeditor vehicles manufactured with a single cross-member behind the engine and equipped with a front engine power take off (FEPTO). The mounting brackets of the first cross member behind the engine may fail prematurely due to strain caused by improper spacing between the cross members, causing the supportive cross member to become loose and detach from the frame rails.
CONSEQUENCE
No Data
REMEDY
Autocar will notify owners, and dealers will replace any damaged components as well as install additional support brackets and an additional cross member, free of charge. Autocar issued owners an interim notification on September 18, 2020. Owners may contact Autocar's customer service at 1-888-218-3611 or 1-877-973-3486. Autocar's number for this recall is ACX-2003. Note: These vehicles were separated out of the previous Autocar recall (19V-456) due to their unique configuration.
NOTES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
SUMMARY
Autocar, LLC (Autocar) is recalling certain 2013-2020 Xpeditor vehicles. The ignition relay may fail without warning, causing the vehicle to stall.
CONSEQUENCE
No Data
REMEDY
Autocar will notify owners, and dealers will replace the ignition relay, free of charge. Autocar issued owners an interim notification on March 12, 2020. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3486. Autocar's number for this recall is ACX-2001.
NOTES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
SUMMARY
Autocar, LLC (Autocar) is recalling certain 2013-2018 Autocar Xpeditor vehicles. The drive shaft support cross member may fail.
CONSEQUENCE
No Data
REMEDY
Autocar will notify owners, and dealers will install additional support brackets and cross members and replace any damaged components, free of charge. Autocar issued owners an interim notification on August 7, 2019. The recall began October 13, 2020. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3486. Autocar's number for this recall is ACX-1906.
NOTES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
SUMMARY
Autocar, LLC (Autocar) is recalling certain 2016-2020 Autocar Xpeditor vehicles equipped with Wabco Automatic Traction Control (ATC) electronic control units (ECU). The ATC ECUs may not be programmed correctly and may malfunction without warning.
CONSEQUENCE
No Data
REMEDY
Autocar will notify owners, and dealers will reprogram the ATC ECU, free of charge. Owners may contact Autocar customer service at 1-888-218-3611 or 1-877-973-3486. The recall began July 6, 2020. Autocar's number for this recall is ACX-2002.
NOTES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
SUMMARY
Autocar, LLC (Autocar) is recalling certain 2012-2016 Xpert, 2010-2020 Xspotter, 2008-2020 Xpeditor, 2008-2010 WXLL and WX vehicles. A worn parking brake control valve can leak air into the vent line, creating excessive back pressure and causing the parking brake to release unexpectedly.
CONSEQUENCE
No Data
REMEDY
Dealers will remove the vent line and fitting from the valve, free of charge. Owner notification letters were mailed March 23, 2023. Owners may contact Autocar customer service at 1-888-218-3611. Autocar's number for this recall is ACX-2023 ACTT-2301.
NOTES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
SUMMARY
Autocar, LLC (Autocar) is recalling certain 2016-2023 ACX (Xpeditor) and 2021-2023 DC (Legend) vehicles. The park brake warning light may incorrectly illuminate during an air loss event. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
CONSEQUENCE
No Data
REMEDY
Dealers will replace the pressure switch, free of charge. Owner notification letters are expected to be mailed December 14, 2023. Owners may contact Autocar customer service at 1-888-218-3611. Autocar's numbers for this recall are ACX-2311 and DC-2306. This recall is an expansion of recall number 23V-400.
NOTES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
SUMMARY
Autocar, LLC (Autocar) is recalling certain 2016-2023 ACX (Xpeditor) and 2020-2023 DC (Legend) vehicles. The park brake warning light may incorrectly illuminate during an air loss event. As such, these trucks fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control and Displays."
CONSEQUENCE
No Data
REMEDY
Dealers will replace the pressure switch, free of charge. Owner notification letters were mailed July 31, 2023. Owners may contact Autocar customer service at 1-888-218-3611. Autocar's numbers for this recall is ACX-2307 and DC-2303.
NOTES
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
